2006 Volkswagen Jetta Recall List
4 safety recall campaigns on file with NHTSA for the 2006 Volkswagen Jetta, affecting fuel system, transmission & powertrain, electrical system, and visibility & wipers. Recall repairs are free at any authorized Volkswagen dealer.
- Recall campaigns
- 4
- Do Not Drive
- 0
- Park Outside
- 0
- Over-the-air fixes
- 0
- Latest report
- Dec 10, 2010
- Owner complaints
- 580
All 2006 Volkswagen Jetta recalls
Newest first. Summaries are NHTSA’s own wording.
- NHTSA 10V621000Dec 10, 2010Fuel System228,236 vehicles
Fuel system, gasoline:delivery:hoses, lines/piping, and fittings
Volkswagen is recalling certain model year 2006-2010 jetta, new beetle, new beetle convertible, model year 2009 jetta sportwagen and model year 2007-2009 rabbit vehicles equipped with 2.5l engines. The jetta, jetta sportwagen, and rabbit vehicles may have a small plastic tab located on the windshield washer fluid reservoir that may chafe against an underhood fuel supply line. The new beetle and the new beetle convertible vehicles may have a fastening clamp on a hydraulic hose of the power steering system that may be located in an improper position which could cause chafing against an underhood fuel supply line.
Risk: If chafing occurs, there is the potential for a fuel leak to develop. Fuel leakage, in the presence of an ignition source, could result in a fire.
Remedy: Dealers will inspect and if necessary replace the underhood fuel line. Additionally, depending on the vehicle model, dealers will either remove the plastic tab from the windshield washer fluid reservoir, or inspect the position of the fastening clamp and adjust the related fastening clamp into the correct position. This service will be performed free of charge. The safety recall is expected to begin on or before january 31, 2011. Owners may contact volkswagen at 1-800-822-8987.
- NHTSA 09V164000May 19, 2009Transmission & Powertrain25,594 vehicles
Power train:driveline:driveshaft
Volkswagen is recalling 25,594 my 2006-2009 jetta 5th generation equipped with 2.01 engine. The fastening screw contact surfaces on the driveshaft cover plate may not have been manufactured to factory specifications. Some screws may not have been torqued properly during assembly and could loosen over time, causing a knocking sound when the vehicle is in motion. The driveshaft screws could loosen to the point where the driveshaft detaches from the gearbox.
Risk: If the vehicle is moving when this happens, the detached driveshaft could cause damage the gearbox housing. A damage gearbox housing could leak gearbox oil onto the street and create a risk of a vehicle crash for both the driver and other motorists.
Remedy: Dealers will inspect the driveshaft screws and replace the screws free of charge. The recall began on june 24, 2009. Owners may contact volkswagen at 1-800-822-8987.
- NHTSA 07V442000Sep 24, 2007Electrical System340,000 vehicles
Exterior lighting:headlights
Certain vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." some vehicles may not have had a required cap installed which disables the headlight horizontal aim and some vehicles may contain a cap that disables the vertical aiming screw.
Risk: Noncompliance can inhibit proper headlamp aim adjustment for roadway illumination, improperly aimed headlamps could cause reduced road visibility, increasing the risk of a crash.
Remedy: Dealers will inspect for the presence of a cap in the socket of the low beam horizontal aiming screw and install one if missing, and inspect for the presence of a cap in the socket of the vertical aiming screw and if present, the cap will be removed. The recall will begin on october 31, 2007. Owners may contact vw at 1-800-822-8987.
- NHTSA 07V284000Jun 25, 2007Visibility & Wipers58,900 vehicles
Visibility:windshield wiper/washer
Certain vehicles equipped with 2.5l gasoline engines may have a small plastic tab located on the windshield washer fluid reservoir that may chafe against the underhood fuel supply line.
Risk: If this happens, the chafing has the potential to cause a fuel leak over time. Fuel leakage in the presence of an ignition source could result in a fire.
Remedy: Dealers will remove the plastic tab from the windshield washer fluid reservoir and will also inspect and, if necessary, replace the underhood fuel supply line. The recall began on august 24, 2007. Owners may contact vw at 1-800-893-5298.
Frequently asked questions
- How many recalls does the 2006 Volkswagen Jetta have?
- NHTSA lists 4 recall campaigns for the 2006 Volkswagen Jetta, covering fuel system, transmission & powertrain, electrical system, and visibility & wipers.
- Are 2006 Volkswagen Jetta recall repairs free?
- Yes. Under U.S. law, manufacturers must fix safety recalls free of charge at authorized dealers, regardless of the vehicle’s age or how many owners it has had. Use the VIN check to see which campaigns are still open on a specific car.
- What is the most recent recall on the 2006 Volkswagen Jetta?
- The most recent campaign is NHTSA 10V621000, reported Dec 10, 2010, concerning the fuel system.